Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.
Cat
3412C Generator Set
Overview
Photos
360° View
Exterior
360° Exterior view. Double click on the image to zoom in on any area of the product.
Showroom
3412C (60), Virtual Product Tour
Features
Specifications
-
Generator Set Specifications
Spec Value Maximum Rating 800 ekW Minimum Rating 635 ekW Emissions/Fuel Strategy Low Fuel Consumption Voltage 220 to 480 Volts Frequency 60 Hz Speed 1800 rpm Duty Cycle Standby, Prime -
Engine Specifications
Spec Value Engine Model 3412C TA, V-12, 4-Stroke Water-Cooled Diesel Bore 5.4 in Stroke 6 in Displacement 1648.86 in³ Compression Ratio 13:00:01 Aspiration TA Fuel System Pump and Lines Governor Type ADEM™ A5 -
Generator Set Dimensions
Spec Value Length - Maximum 162.4 in Width - Maximum 78.3 in Height - Maximum 75 in Dry Weight - Genset (minimum) 5761 lb Dry Weight - Genset (maximum) 13275 lb
Standard Equipment
Air Inlet System
- Air cleaner, single element canister type
- Single element canister type
Control Panel
- High coolant temperature
- Customer data link (Modbus RTU)
- Low coolant temperature
- Low coolant level
- Communications:
- Run/auto/ stop/control
- Engine cycle crank
- Generator temperature monitoring module
- Power factor (per phase & average)
- Remote CAN annunciator
- Serial annunciator module data link
- DC volts
- Frequency (Hz)
- Operating hours.
- Emergency stop pushbutton
- Digital I/O module
- Local annunciator
- Low oil pressure
- Oil pressure (psi, kPa or bar)
- Emergency stop
- Warning shutdowns:
- Volts (L-L & L-N)
- Remote Serial annunciator
- Speed adjust
- Amps (per phase & average)
- Voltage adjust
- EMCP 4.2B
- Overspeed
- coolant temperature
- Digital Indicator for:
- RPM
- Accessory module data link
- Failure to start (overcrank)
- Controls:
- Compatible with the following optional modules:
Cooling System
- Caterpillar extended life coolant
- Radiator with guard (sized for 50 degrees C)
- Fan and belt guards
- Coolant drain line with valve
Exhaust System
- Stainless steel exhaust flex with ANSI style outlet flange
Fuel System
- Primary and Secondary fuel filters
- Fuel priming pump
- Water separator
Generator and Attachments
- 3 Phase sensing
- SR4B self excited
- Class F temperature rise
- VR6B voltage regulator
- Busbar termination
- 12 Leads
- Class H insulation
- 2:1 Volts/Hz
- Reactive droop
Governing System
- Cat electronic governor
Lube System
- Oil drain line with valve
- Lubricating oil
- Oil filter
Mounting System
- Base, formed steel with linear vibration isolators between base and engine-generator
Starting / Charging System
- Battery with rack, cables
- 45 Amp Charging alternator
- Fuel shutoff solenoid
- 24 Volt starting motor
General
- Paint - Caterpillar yellow except rails and radiators gloss black
Optional Equipment
Air Inlet System
- Air cleaner - Dual element
- Air cleaner - Heavy element
- Air cleaner - single element
Certificates
- EU Certification
Circuit breakers
- 4 Pole Circuit breakerswith shunt trip
- 3 Pole Circuit breakers with shunt trip
- Power terminal strip
Control Panel
- EMCP 4.3, EMCP 4.4
- Temperature monitoring package
- Vandal proof panel door
- Generator running VFC
- Earth leakage Ground fault relay
- Common alarm/shutdown relay
Cooling System
- Jacket water heater
- Radiator duct flange
- Radiator removal
Exhaust System
- Muffler 10 dBA attenuation
- Manifold and turbocharger guards
- Muffler 35 dBA attenuation
- Elbow mounting kit
- Through wall installation kit
Fuel System
- Manual fuel transfer pump
- Automatic fuel transfer system
Generator and Attachments
- Internal excitation (IE)
- Anti-condensation heater
- Permanent magnet excitation (PMG)
- Oversize and premium generators
Governing System
- Electronic load share
Lube System
- Manual sump pump
Mounting System
- Fuel tank base (1200 Ltr)
Special Tests / Reports
- PGS Test report @ 1.0 power factor
- PGS Test report @ 0.8 power factor
- Factory witness test
Starting / Charging system
- Oversize battery set
- Battery chargers
- Heavy duty starting system
- Battery disconnect switch
- Battery removal
Enclosures
- DC lighting package
- Weather protective enclosure (WP)
- Sound attenuated enclosure (SA)
Sign up for Ziegler CAT emails
Events, updates, and offers