Condition

• GENERAL CONDITION

  Item	Condition
  ET Product Status Report Download	Yes
  Logged / Active Codes	Yes Machine two active codes. One for product link and one for GPS antenna.
  Machine Starts and is Operable	Yes
  Visible Oil Leaks	No
  Body	●●●
  Frame	●●●
  General	●●●

• GENERAL APPEARANCE

  Item	Condition
  Bumper	●● Cab bumper is dented.
  Car Body	●●●
  Catwalk	●●●
  Counterweight	●●● Counterweight has fist size gouge
  Crankcase Guard / Battery Box	●● Battery compartment door is bent and hard to shut.
  Decals	●●●
  Draw Bar	●●●
  Eng. Enclose Hood / Stack	●●● Hood seal is falling off.
  Engine Doors	●●●
  Fuel Tank	●●● Fuel tank cap breather is cracked.
  Grab Irons	●●●
  Hood	●●●
  Main Frame Welds	●●●
  Paint	●●●
  Plastic	●●●
  Pre-Cleaner Bowl	●●●
  Radiator Grill & Shroud	●●● Door seal bracket is bent.
  Sheet Metal	●●●
  Steps / Ladder	●●●

• SAFETY ITEMS

  Item	Condition
  ROPS	Yes
  ROPS Certification Plate	Yes
  Safety Decals In Place	Yes
  Safety Decals Legible	Yes
  Camera(s)	●●●
  Horn	● Horn is inop
  Seat Belt / Date	●●●
  Travel Alarm	●●●

• OPERATOR STATION

  Item	Condition
  Diesel Exhaust Fluid (DEF) Level - OPERATOR STATION	Low
  Fuel Level - OPERATOR STATION	3/4 full
  Current O&MM	Yes
  Air Conditioner	●● A/C blows cold at 48 degrees. Compressor is making high pitched sound.
  Armrests	●●●
  Cab Filter / Heat Vent Louvres	●● Cab air filter door is held shut with wire
  Dash Console	●●●
  Door Latches / Hinges / Seals	●●●
  Floor Boards / Mats	●●●
  Gauges	●●●
  Headliner	●●●
  Heater / Defroster	●●●
  Hour Meter - GAUGES, OPERATION STATION, CONSOLE	●●●
  Hydraulic Controls	●● Left hand joystick handle rubber is coming off from automatics controller clamp.
  Interior Lights	●●●
  Interior Plastic / Fabric	●● Door latch cover is missing.
  Mirrors	●●●
  Monitoring Display	●●●
  Pans/Guards	●●●
  Radio	●●●
  Seat Cushions / Suspension / Type	●●● Seat has small tear.
  Switches	●●●
  Travel Controls (Type)	●●●
  Visor / Sunshade	●●●
  Windows	●● Front window latch is stuck and cannot open front window.
  Windshield Wipers	●● Lower wiper arm works but is bent. Washer fluid hose is broken off.

• ENGINE

  Item	Condition
  Apparent Other Engine Damage	No
  Blow By	No
  Emissions Decal Legible	Yes
  Fuel Leaks	No
  Knocking	No
  Oil Leaks	Yes Engine oil pan has level 2 leak.
  Service Needed	Yes Last PM was at 5804 hours according to writing on filters.
  Water in Oil	No
  Oil Pressure (H/L/N)	Good
  Smoke Color (B/D/L/W)	None
  Belts / Pulleys - ENGINE	●●●
  Engine Oil Level / Condition	●●●
  Engine Supports / Mounts	●●●
  Exhaust / Muffler / Stack	●● NRS crossover pipe has signs of exhaust leaks cant see or hear any leaks when running.
  Fuel Injection System	●●●
  Governor	●●●
  Intake / Air Filters	●● Filters are dirty but not plugged.
  Operating Condition - ENGINE	●●●
  Other	●●●
  Turbocharger / Blower	●●●

• EMISSIONS

  Item	Condition
  Aftertreatment System Codes	No
  Leaks / Type	No
  Aftertreatment Heat Shields / Guards	●●●
  DEF Lines / Wiring	●●●
  Diesel Exhaust Fluid (DEF) Tank	●●●
  Diesel Particulate Filter (DPF) Condition / Service Hours	●●● DPF ash service was performed at 5209 hours.

• COOLING SYSTEM

  Item	Condition
  Compression in Radiator	No
  Coolant Leaks	Yes
  Standard Radiator	Yes
  Anti-Freeze Level / Color / Condition	●●●
  Belts / Pulleys - COOLING SYSTEM	●●●
  Coolers	●●●
  Fan	●●●
  Fan Drive / Type	●●●
  Fan Shrouds / Guards	●●●
  Hoses / Tubes	●● Both lines on expansion tank are cracking. Lower water pump hose has level 2 leak. Bottom radiator hose has level 2 leak.
  Radiator	●●●
  Water Pump	●●●

• ELECTRICAL, STARTING AND CHARGING SYSTEM

  Item	Condition
  Block Heater	Yes
  Ether Aid	Yes
  Alternator	●●●
  Batteries / Cables / Master Disconnect	●●●
  Lighting	● Left cab light is out. Both boom lights are out. Light on toolbox is out.
  Starter	●●●
  Wiring	●●●

• HYDRAULICS

  Item	Condition
  Swing Drive Oil Level	Both are full.
  Boom Cylinder	●●●
  Bucket Cylinder	●●●
  Control Linkage	●●●
  Filter Condition (CUT)	●●
  Hose Lines	●● Main suction hose from tank has level 2 leak
  Hydraulic Swivel	●● Oil leak coming from swivel area.
  Operating Condition - HYDRAULICS	●●●
  Pump Drive	●● Pump coupler has level 2 leak and is low on oil.
  Pumps & Valves	●●●
  Rotex	●●●
  Stick Cylinder	●●● Stick cylinder clamp is missing bolts.
  Swing Gear	●●●
  Swing Motors	●●●
  Tank	●●● Oil level is low.
  Travel Motors	●●

• TECHNOLOGY

  Item	Condition
  Technology System Operational	No
  Boom Sensor	●●●
  Bucket Sensor	●●●
  GNSS Antennas #1	●●●
  GNSS Antennas #2	●●●
  GPS Wiring Harness	●● Laser catcher harnesses is missing
  Grade Display	● Trimble monitor is not turning on.
  Machine Display	●●●
  Stick Sensor	●●●
  Tilt / Bucket Sensor Harness	●●●

• BOOM

  Item	Condition
  Notes - BOOM	Boom is tight
  Boom Condition	●●●
  Boom Pins	●●●
  Pins & Bushings - BOOM	●●●

• STICK

  Item	Condition
  Notes - STICK	Stick is tight.
  Pins & Bushings - STICK	●●●
  Stick Conditions	●●●
  Stick Pins	●●●

• UNDERCARRIAGE

  Item	Condition
  Pins & Bushings Turned?	No
  Link Part Number	5162630
  Track Frame - Left	●●●
  Track Frame - Right	●●●
  Carrier Rollers Front	Left     Right
  Carrier Rollers Rear	Left     Right
  Idlers Front	Left     Right
  Links	Left     Right
  Pins & Bushings (External)	Left     Right
  Pins & Bushings (Internal)	Left     Right
  Track Roller 1	Left     Right
  Track Roller 2	Left     Right
  Track Roller 3	Left     Right
  Track Roller 4	Left     Right
  Track Roller 6	Left     Right
  Track Roller 7	Left     Right
  Track Roller 8	Left     Right
  Track Roller 9	Left     Right
  Track Shoe Grouser Height	Left     Right

• FINAL DRIVES

  Item	Condition
  Magnetic Plugs Removed & Checked?	Yes Left side final drive oil looked a little milky.
  Housings, Left	●●●
  Housings, Right	●●●
  Planetaries / Differential, Left	●●●
  Planetaries / Differential, Right	●●●