2012 CAT 320E 6,471 engine hrs
Condition
| ET Product Status Report Download | Yes | |
|---|---|---|
| Logged / Active Codes | No | |
| Machine Starts and is Operable | Yes | |
| Visible Oil Leaks | No | |
| Body | ||
| Frame | ||
| General |
| Bumper | Dented | |
|---|---|---|
| Car Body | ||
| Catwalk | ||
| Counterweight | ||
| Crankcase Guard / Battery Box | ||
| Decals | Missing boom decals. | |
| Draw Bar | Right rear pull point is bent | |
| Eng. Enclose Hood / Stack | ||
| Engine Doors | Minor dent on the edge pump door | |
| Fuel Tank | ||
| Grab Irons | Bent and cracking | |
| Hood | ||
| Main Frame Welds | ||
| Paint | ||
| Pre-Cleaner Bowl | ||
| Radiator Grill & Shroud | ||
| Sheet Metal | Tool box latch has been removed. | |
| Steps / Ladder | Step on tool box bent. Left rear step is bent a little |
| Parking Brake Functioning | Yes | |
|---|---|---|
| ROPS | Yes | |
| Safety Decals In Place | Yes | |
| Safety Decals Legible | Yes | |
| Service Brakes Functioning | Yes | |
| Camera(s) | ||
| Horn | ||
| Seat Belt / Date | ||
| Secondary Exit | ||
| Travel Alarm |
| Fuel Level - OPERATOR STATION | Full | |
|---|---|---|
| Current O&MM | Yes | |
| Current Safety Manual | Yes | |
| Air Conditioner | ||
| Armrests | ||
| Cab Filter / Heat Vent Louvres | ||
| Dash Console | ||
| Door Latches / Hinges / Seals | Front window bottom seal coming off. Door handle plastic is missing | |
| Floor Boards / Mats | ||
| Gauges | ||
| Headliner | ||
| Heater / Defroster | ||
| Hour Meter - GAUGES, OPERATION STATION, CONSOLE | ||
| Hydraulic Controls | ||
| Interior Lights | Not working | |
| Interior Plastic / Fabric | ||
| Mirrors | ||
| Monitoring Display | ||
| Radio | ||
| Seat Cushions / Suspension / Type | Seat back has a hole. Suspension covering is coming off on the bottom. | |
| Switches | ||
| Travel Controls (Type) | ||
| Visor / Sunshade | ||
| Windows | ||
| Windshield Wipers | Bottom sprayer don’t work |
| Blow By | No | |
|---|---|---|
| Emissions Decal Legible | Yes | |
| Fuel Leaks | No | |
| Knocking | No | |
| Oil Leaks | No | |
| Service Needed | No | Last serviced at 8831hrs |
| Water in Oil | No | |
| Notes - ENGINE | Engine looks like the egr cooler was replaced 2-5-26 | |
| Oil Pressure (H/L/N) | Normal | |
| Smoke Color (B/D/L/W) | Normal | |
| Belts / Pulleys - ENGINE | ||
| Engine Oil Level / Condition | ||
| Engine Supports / Mounts | ||
| Exhaust / Muffler / Stack | ||
| Fuel Injection System | ||
| Governor | ||
| Intake / Air Filters | ||
| Operating Condition - ENGINE | ||
| Turbocharger / Blower |
| Aftertreatment System Codes | No | |
|---|---|---|
| Leaks / Type | No | |
| Aftertreatment Heat Shields / Guards | ||
| Diesel Exhaust Fluid (DEF) Tank | ||
| Diesel Particulate Filter (DPF) Condition / Service Hours |
| Compression in Radiator | No | |
|---|---|---|
| Coolant Leaks | Yes | |
| Oil in Anti-Freeze | No | |
| Standard Radiator | Yes | |
| Anti-Freeze Level / Color / Condition | -35F | |
| Belts / Pulleys - COOLING SYSTEM | ||
| Coolers | ||
| Fan | ||
| Fan Drive / Type | ||
| Fan Shrouds / Guards | ||
| Hoses / Tubes | ||
| Radiator | Level 1 leak at the drain valve | |
| Water Pump |
| Ether Aid | Yes | |
|---|---|---|
| Notes - ELECTRICAL, STARTING AND CHARGING SYSTEM | On 2-5-26 machine had the Titan air shut off disabled due to cause an error with the charging system. | |
| Alternator | ||
| Batteries / Cables / Master Disconnect | ||
| Lighting | ||
| Pre-Heater | ||
| Starter | ||
| Wiring |
| Swing Drive Oil Level | Full | |
|---|---|---|
| Boom Cylinder | ||
| Bucket Cylinder | ||
| Control Linkage | ||
| Hose Lines | ||
| Hydraulic Swivel | ||
| Operating Condition - HYDRAULICS | ||
| Pump Drive | ||
| Pumps & Valves | ||
| Rotex | ||
| Stick Cylinder | ||
| Swing Gear | ||
| Swing Motors | ||
| Tank | ||
| Travel Motors |
| Boom Length (Actual Length) | 223” | |
|---|---|---|
| Boom Condition | ||
| Boom Pins | ||
| Pins & Bushings - BOOM | 1/8 to 3/16 play at base pin |
| Stick Length | 123” | |
|---|---|---|
| Pins & Bushings - STICK | Stick to bucket bushings have 1/4” play up and down. Bucket has 3/8” side to side | |
| Stick Conditions | ||
| Stick Pins |
| Brand | Cat | |
|---|---|---|
| Width | 36” | |
| Bucket Bottom | Dented | |
| Bucket Linkage | Missing o rings. | |
| Bucket Mounts | ||
| Bucket Sides | ||
| Cutting Edges | ||
| Teeth / Adapters | Has edge welded to it |
| Pins & Bushings Turned? | No | |
|---|---|---|
| Link Part Number | 9w3138 | |
| Track Frame - Left | ||
| Track Frame - Right | ||
| Carrier Rollers Front |
Left Measurement: 118 Left Percent Worn: 10% Right Measurement: 116 Right Percent Worn: 22% |
|
| Carrier Rollers Rear |
Left Measurement: 116 Left Percent Worn: 22% Right Measurement: 117 Right Percent Worn: 16% |
|
| Idlers Front |
Left Measurement: 20 Left Percent Worn: 6% Right Measurement: 20 Right Percent Worn: 6% |
|
| Links |
Left Measurement: 103 Right Measurement: 103 |
|
| Pins & Bushings (External) |
Left Measurement: 57 Left Percent Worn: 73% Right Measurement: 57 Right Percent Worn: 73% |
|
| Pins & Bushings (Internal) |
Left Measurement: 765 Left Percent Worn: 34% Right Measurement: 765 Right Percent Worn: 34% |
|
| Track Roller 1 |
Left Measurement: 119 Left Percent Worn: 21% Right Measurement: 119 Right Percent Worn: 21% |
|
| Track Roller 2 |
Left Measurement: 119 Left Percent Worn: 21% Right Measurement: 119 Right Percent Worn: 21% |
|
| Track Roller 3 |
Left Measurement: 119 Left Percent Worn: 21% Right Measurement: 119 Right Percent Worn: 21% |
|
| Track Roller 4 |
Left Measurement: 119 Left Percent Worn: 21% Right Measurement: 119 Right Percent Worn: 21% |
|
| Track Roller 5 |
Left Measurement: 119 Left Percent Worn: 21% Right Measurement: 119 Right Percent Worn: 21% |
|
| Track Roller 6 |
Left Measurement: 119 Left Percent Worn: 21% Right Measurement: 119 Right Percent Worn: 21% |
|
| Track Roller 7 |
Left Measurement: 119 Left Percent Worn: 21% Right Measurement: 119 Right Percent Worn: 21% |
|
| Track Roller 8 |
Left Measurement: 119 Left Percent Worn: 21% Right Measurement: 119 Right Percent Worn: 21% |
|
| Track Shoe Grouser Height |
Left Measurement: 24 Left Percent Worn: 8% Right Measurement: 24 Right Percent Worn: 8% |
| Magnetic Plugs Removed & Checked? | Yes | |
|---|---|---|
| Housings, Left | ||
| Housings, Right | ||
| Planetaries / Differential, Left | ||
| Planetaries / Differential, Right |
Comments
A/C
HEATER
LIGHTS
RADIO
PATTERN CHANGER
31" TG SHOES
ETHER AID
REAR CAMERA
9'6" STICK
DIG BUCKET
Features