2020 CAT 257D3 3,060 engine hrs
Condition
| Logged / Active Codes | Yes | |
|---|---|---|
| Machine Starts and is Operable | Yes | |
| Visible Oil Leaks | No | |
| Body | ||
| Frame | ||
| General |
| Cleaning Required | No | |
|---|---|---|
| Bumper | ||
| Cab or Canopy | ||
| Crankcase Guard / Battery Box | ||
| Decals | Decals show wear | |
| Eng. Enclose Hood / Stack | ||
| Fuel Tank | ||
| Grab Irons | ||
| Main Frame Welds | ||
| Paint | ||
| Plastic | ||
| Radiator Grill & Shroud | Gas strut wont hold grill up | |
| Sheet Metal | ||
| Steps / Ladder |
| Parking Brake Functioning | Yes | |
|---|---|---|
| ROPS Certification Plate | Yes | |
| Safety Decals In Place | Yes | |
| Safety Decals Legible | Yes | |
| Back Up Alarm | ||
| Camera(s) | ||
| Dead Engine Lowering Valve | ||
| Horn | ||
| ROPS | ||
| Safety Locks / Pins | ||
| Seat Belt / Date | Works but out of date. | |
| Secondary Exit |
| Fuel Level - OPERATOR STATION | 100% | |
|---|---|---|
| Current O&MM | Yes | |
| Current Safety Manual | Yes | |
| Sound Proofing | Yes | |
| Air Conditioner | ||
| Armrests | ||
| Cab Filter / Heat Vent Louvres | 1 cab vent broken. | |
| Dash Console | ||
| Door Latches / Hinges / Seals | Seal loose. | |
| Floor Boards / Mats | ||
| Gauges | ||
| Headliner | ||
| Heater / Defroster | ||
| Hour Meter - GAUGES, OPERATION STATION, CONSOLE | ||
| Hydraulic Controls | ||
| Interior Lights | ||
| Interior Plastic / Fabric | ||
| Mirrors | ||
| Monitoring Display | ||
| Radio | ||
| Seat Cushions / Suspension / Type | ||
| Switches | ||
| Windows | ||
| Windshield Wipers |
| Apparent Other Engine Damage | No | |
|---|---|---|
| Blow By | No | |
| Emissions Decal Legible | Yes | |
| Fuel Leaks | No | |
| Knocking | No | |
| Oil Leaks | No | |
| Service Needed | No | |
| Water in Oil | No | |
| Oil Pressure (H/L/N) | Normal | |
| Smoke Color (B/D/L/W) | Normal | |
| Belts / Pulleys - ENGINE | Belts worn and cracked. | |
| Engine Oil Level / Condition | ||
| Engine Supports / Mounts | ||
| Exhaust / Muffler / Stack | ||
| Fuel Injection System | ||
| Governor | ||
| Intake / Air Filters | Should be changed at next PM | |
| Operating Condition - ENGINE | ||
| Turbocharger / Blower |
| Aftertreatment System Codes | No | |
|---|---|---|
| Leaks / Type | No | |
| Aftertreatment Heat Shields / Guards | ||
| Diesel Particulate Filter (DPF) Condition / Service Hours | Just cleaned |
| Compression in Radiator | No | |
|---|---|---|
| Coolant Leaks | No | |
| Oil in Anti-Freeze | No | |
| Standard Radiator | Yes | |
| Anti-Freeze Level / Color / Condition | ||
| Belts / Pulleys - COOLING SYSTEM | Belts worn | |
| Coolers | ||
| Fan | ||
| Fan Drive / Type | Level 1 leak on shaft seal. Collecting dust. | |
| Fan Shrouds / Guards | ||
| Hoses / Tubes | ||
| Radiator | ||
| Water Pump |
| Block Heater | Yes | |
|---|---|---|
| Alternator | ||
| Batteries / Cables / Master Disconnect | ||
| Lighting | 1 rear flood inoperative | |
| Pre-Heater | ||
| Starter | ||
| Wiring |
| Housings, Left | ||
|---|---|---|
| Housings, Right | ||
| Lines / Linkages | ||
| Operating Condition | ||
| Planetaries / Differential, Left | ||
| Planetaries / Differential, Right | ||
| Torsion Axles | ||
| Travel Controls | ||
| Travel Motors | ||
| Travel Pumps |
| Hoses / Lines | ||
|---|---|---|
| Lift Cylinders | ||
| Overall Operating Condition - HYDRAULICS | ||
| Pump & Valves | ||
| Tank | ||
| Tilt Cylinder | Wont take grease. |
| Bucket Bottom | Worn and dented. | |
|---|---|---|
| Bucket Linkage | 3/8” freeplay | |
| Bucket Sides | ||
| Cutting Edges | 25% | |
| Loader Frame | ||
| Loader Pins & Bushings | 1/4” freeplay. | |
| Quick Coupler |
| Track / Belt Tread Thickness | 1 3/4” | |
|---|---|---|
| Track / Belt Width | 14 3/4” | |
| Idlers | Show wear | |
| Roller | Roolers show wear | |
| Roller Frame | ||
| Sprocket | Rollers worn,but not to bad. | |
| Track / Belt Condition | 60% remaining |
Features