2023 CAT 279D3 2,864 engine hrs
Condition
| Logged / Active Codes | No | |
|---|---|---|
| Machine Starts and is Operable | Yes | |
| Visible Oil Leaks | No | |
| Body | ||
| Frame | ||
| General |
| Cleaning Required | No | |
|---|---|---|
| Cab or Canopy | ||
| Crankcase Guard / Battery Box | ||
| Decals | ||
| Eng. Enclose Hood / Stack | ||
| Fuel Tank | ||
| Grab Irons | ||
| Main Frame Welds | ||
| Paint | ||
| Radiator Grill & Shroud | ||
| Sheet Metal | ||
| Steps / Ladder |
| Parking Brake Functioning | Yes | |
|---|---|---|
| ROPS Certification Plate | Yes | |
| Safety Decals In Place | Yes | |
| Safety Decals Legible | Yes | |
| Back Up Alarm | ||
| Camera(s) | ||
| Dead Engine Lowering Valve | ||
| Horn | ||
| ROPS | ||
| Safety Locks / Pins | ||
| Seat Belt / Date | ||
| Secondary Exit |
| Diesel Exhaust Fluid (DEF) Level - OPERATOR STATION | N/A | |
|---|---|---|
| Fuel Level - OPERATOR STATION | Full | |
| Current O&MM | Yes | |
| Air Conditioner | A/C blows cold at 50 degrees. 88 degrees outside. | |
| Armrests | ||
| Cab Filter / Heat Vent Louvres | Lower bolt for cover is missing. Cover is held in with screw. | |
| Dash Console | ||
| Door Latches / Hinges / Seals | ||
| Floor Boards / Mats | ||
| Gauges | ||
| Headliner | ||
| Heater / Defroster | ||
| Hour Meter - GAUGES, OPERATION STATION, CONSOLE | ||
| Hydraulic Controls | ||
| Interior Lights | ||
| Interior Plastic / Fabric | ||
| Mirrors | ||
| Monitoring Display | ||
| Radio | Radio works but is cracked. | |
| Seat Cushions / Suspension / Type | ||
| Switches | ||
| Windows | ||
| Windshield Wipers |
| Blow By | No | |
|---|---|---|
| Fuel Leaks | No | |
| Knocking | No | |
| Oil Leaks | No | |
| Pre Lube System | No | |
| Service Needed | No | Last service was at 2628 hours |
| Water in Oil | No | |
| Oil Pressure (H/L/N) | Normal | |
| Smoke Color (B/D/L/W) | None | |
| Belts / Pulleys - ENGINE | ||
| Engine Oil Level / Condition | ||
| Engine Supports / Mounts | ||
| Exhaust / Muffler / Stack | ||
| Fuel Injection System | ||
| Governor | ||
| Intake / Air Filters | ||
| Operating Condition - ENGINE | ||
| Turbocharger / Blower |
| Aftertreatment System Codes | No | |
|---|---|---|
| Leaks / Type | No | |
| Aftertreatment Heat Shields / Guards | ||
| Diesel Particulate Filter (DPF) Condition / Service Hours | Soot load is at 21% |
| Compression in Radiator | No | |
|---|---|---|
| Coolant Leaks | No | |
| Oil in Anti-Freeze | No | |
| Standard Radiator | Yes | |
| Anti-Freeze Level / Color / Condition | ||
| Belts / Pulleys - COOLING SYSTEM | ||
| Coolers | ||
| Fan | ||
| Fan Drive / Type | ||
| Fan Shrouds / Guards | ||
| Hoses / Tubes | ||
| Radiator | ||
| Water Pump |
| Block Heater | Yes | |
|---|---|---|
| Alternator | ||
| Batteries / Cables / Master Disconnect | ||
| Lighting | ||
| Pre-Heater | ||
| Starter | ||
| Wiring |
| Magnetic Plugs Removed & Checked? | Yes | |
|---|---|---|
| Housings, Left | ||
| Housings, Right | ||
| Lines / Linkages | ||
| Operating Condition | ||
| Planetaries / Differential, Left | ||
| Planetaries / Differential, Right | ||
| Torsion Axles | Front and rear torsion axel bushings have 1/4” of play. Front left axle did not take grease. Both rear axles have broken grease fittings. | |
| Travel Controls | ||
| Travel Motors | ||
| Travel Pumps |
| Leaks - HYDRAULICS | No | |
|---|---|---|
| Detent Switch | ||
| Filter Condition (CUT) | ||
| Hoses / Lines | ||
| Lift Cylinders | ||
| Overall Operating Condition - HYDRAULICS | ||
| Pump & Valves | ||
| Tank | ||
| Tilt Cylinder |
| Bucket Bottom | Bucket bottom has holes | |
|---|---|---|
| Bucket Linkage | Coupler to bucket is loose has 1/2” of play. Linkage pins and bushings have 5/16” of play | |
| Cutting Edges | ||
| Loader Frame | ||
| Loader Pins & Bushings | ||
| Quick Coupler |
| Notes - UNDERCARRIAGE | Tracks are cambered out due to worn axle bushings. | |
|---|---|---|
| Idlers | 8mm 75% life left | |
| Roller | 12mm 70% life left | |
| Roller Frame | Fromt roller frame has 1/2” of play. | |
| Sprocket | 172mm 25% life left. Aftermarket sprockets. | |
| Track / Belt Condition | 8mm 0% life left. Tracks are worn down to bars on inside. |
Features