2005 CAT 330CL 21,619 engine hrs
Condition
| ET Product Status Report Download | Yes | |
|---|---|---|
| Logged / Active Codes | Yes | |
| Machine Starts and is Operable | Yes | |
| Visible Oil Leaks | Yes | See hydraulics comments |
| Body | ||
| Frame | House frame under the radiator is bent. | |
| General |
| Bumper | Dented | |
|---|---|---|
| Car Body | ||
| Catwalk | ||
| Counterweight | ||
| Crankcase Guard / Battery Box | Battery box floor is bent up a few inches. | |
| Draw Bar | ||
| Eng. Enclose Hood / Stack | ||
| Engine Doors | Left and right door dented | |
| Fuel Tank | ||
| Grab Irons | ||
| Hood | ||
| Main Frame Welds | ||
| Paint | ||
| Pre-Cleaner Bowl | ||
| Radiator Grill & Shroud | ||
| Sheet Metal | Cab door has a rust hole | |
| Steps / Ladder |
| Parking Brake Functioning | Yes | |
|---|---|---|
| ROPS | No | |
| ROPS Certification Plate | No | |
| Safety Decals In Place | Yes | |
| Safety Decals Legible | Yes | |
| Service Brakes Functioning | Yes | |
| Horn | ||
| Seat Belt / Date | ||
| Secondary Exit | ||
| Travel Alarm |
| Fuel Level - OPERATOR STATION | 2/3 | |
|---|---|---|
| Current O&MM | Yes | |
| Sound Proofing | Yes | |
| Air Conditioner | Blowing 48F | |
| Armrests | ||
| Cab Filter / Heat Vent Louvres | ||
| Dash Console | ||
| Door Latches / Hinges / Seals | Door has a hole on the inside | |
| Floor Boards / Mats | ||
| Gauges | ||
| Headliner | ||
| Heater / Defroster | ||
| Hour Meter - GAUGES, OPERATION STATION, CONSOLE | Hour meter has been replaced and shows 18371 hours, total machine hours are 21619 | |
| Hydraulic Controls | ||
| Interior Lights | Not working | |
| Interior Plastic / Fabric | ||
| Mirrors | ||
| Monitoring Display | ||
| Pans/Guards | ||
| Radio | ||
| Seat Cushions / Suspension / Type | Bottom cushion has hole | |
| Switches | ||
| Travel Controls (Type) | ||
| Windows | Right window is loose from the frame. Front window glass rattles | |
| Windshield Wipers |
| Blow By | Yes | Moderate |
|---|---|---|
| Emissions Decal Legible | Yes | |
| Fuel Leaks | No | |
| Knocking | No | |
| Oil Leaks | Yes | Rocker box has a level 3 leak |
| Water in Oil | No | |
| Engine Oil Level / Condition | ||
| Engine Supports / Mounts | ||
| Exhaust / Muffler / Stack | ||
| Fuel Injection System | Hard starting in cold | |
| Governor | ||
| Intake / Air Filters | Filter is dirty | |
| Operating Condition - ENGINE | Starts hard in the cold. | |
| Turbocharger / Blower |
| Compression in Radiator | No | |
|---|---|---|
| Coolant Leaks | Yes | |
| Oil in Anti-Freeze | No | |
| Standard Radiator | Yes | |
| Anti-Freeze Level / Color / Condition | ||
| Belts / Pulleys - COOLING SYSTEM | Serpentine belt is cracked. | |
| Coolers | ||
| Fan | ||
| Fan Drive / Type | ||
| Fan Shrouds / Guards | ||
| Hoses / Tubes | Heater hose at water shut off valve level 2 leak. | |
| Radiator | ||
| Water Pump |
| Block Heater | Yes | |
|---|---|---|
| Alternator | ||
| Batteries / Cables / Master Disconnect | ||
| Lighting | ||
| Pre-Heater | Machine stars very hard in cold. | |
| Starter | Level 3 leak | |
| Wiring |
| Notes - HYDRAULICS | Has level 3 leak coming from under cab. | |
|---|---|---|
| Swing Drive Oil Level | Full | |
| Boom Cylinder | 1/8” play in bearings | |
| Bucket Cylinder | ||
| Control Linkage | ||
| Hose Lines | Level 1 leaks | |
| Hydraulic Swivel | ||
| Operating Condition - HYDRAULICS | ||
| Pump Drive | ||
| Pumps & Valves | ||
| Rotex | 1/8” movement | |
| Stick Cylinder | ||
| Swing Gear | ||
| Swing Motors | ||
| Tank | ||
| Travel Motors |
| Boom Length (Actual Length) | 21 foot | |
|---|---|---|
| Boom Condition | Has been welded in 4 locations, 3 on right 1 on left | |
| Pins & Bushings - BOOM | 1/8” to on the boom to house pin |
| Stick Length | 12'6" | |
|---|---|---|
| Pins & Bushings - STICK | ||
| Stick Conditions | It’s been repaired in a couple locations | |
| Stick Pins |
| Quick Coupler | Yes | |
|---|---|---|
| Brand | Empire | |
| Width | Empire 60” flat bottom sand bucket | |
| Bucket Bottom | ||
| Bucket Linkage | Missing o rings from stick and h link to coupler. Could use shims to tighten the side to side play | |
| Bucket Mounts | ||
| Bucket Sides | ||
| Cutting Edges | Front face is worn |
| Pins & Bushings Turned? | No | |
|---|---|---|
| Carrier Rollers | Right front has flat spot | |
| Link Part Number | 6y-2589 | |
| Notes - UNDERCARRIAGE 1 | Several bent shoes on both sides | |
| Track Shoes Width / Type | 34” | |
| Track Frame - Left | ||
| Track Frame - Right | ||
| Carrier Rollers Front |
Left Measurement: 158mm Left Percent Worn: 8% Right Measurement: 153mm Right Percent Worn: 28% |
|
| Carrier Rollers Rear |
Left Measurement: 155 Left Percent Worn: 20% Right Measurement: 150 Right Percent Worn: 40% |
|
| Idlers Front |
Left Measurement: 22mm Left Percent Worn: 28% Right Measurement: 22mm Right Percent Worn: 28% |
|
| Links |
Left Measurement: 120mm Left Percent Worn: 56% Right Measurement: 120mm Right Percent Worn: 56% |
|
| Pins & Bushings (External) |
Left Measurement: 64mm Left Percent Worn: 94% Right Measurement: 64mm Right Percent Worn: 94% |
|
| Pins & Bushings (Internal) |
Left Measurement: 872mm Left Percent Worn: 55% Right Measurement: 872mm Right Percent Worn: 55% |
|
| Track Roller 1 |
Left Measurement: 24.5 mm avg Left Percent Worn: 68% Right Measurement: 24.5mm avg Right Percent Worn: 68% |
|
| Track Roller 2 |
Left Measurement: 24.5mm avg Left Percent Worn: 68% Right Measurement: 24.5mm avg Right Percent Worn: 68% |
|
| Track Roller 3 |
Left Measurement: 24.5mm avg Left Percent Worn: 68% Right Measurement: 24.5mm avg Right Percent Worn: 68% |
|
| Track Roller 4 |
Left Measurement: 24.5mm avg Left Percent Worn: 68% Right Measurement: 24.5mm avg Right Percent Worn: 68% |
|
| Track Roller 5 |
Left Measurement: 24.5mm avg Left Percent Worn: 68% Right Measurement: 24.5mm avg Right Percent Worn: 68% |
|
| Track Roller 6 |
Left Measurement: 24.5mm avg Left Percent Worn: 68% Right Measurement: 24.5mm avg Right Percent Worn: 68% |
|
| Track Roller 7 |
Left Measurement: 24.5mm avg Left Percent Worn: 68% Right Measurement: 24.5mm avg Right Percent Worn: 68% |
|
| Track Roller 8 |
Left Measurement: 24.5mm avg Left Percent Worn: 68% Right Measurement: 24.5mm avg Right Percent Worn: 68% |
|
| Track Roller 9 |
Left Measurement: 24.5mm avg Left Percent Worn: 68% Right Measurement: 24.5mm avg Right Percent Worn: 68% |
|
| Track Shoe Grouser Height |
Left Measurement: 21.5 Left Percent Worn: 51% Right Measurement: 20.5 Right Percent Worn: 58% |
| Housings, Left | ||
|---|---|---|
| Housings, Right | ||
| Planetaries / Differential, Left | ||
| Planetaries / Differential, Right |
Comments
A/C
HEATER
LIGHTS
RADIO
PATTERN CHANGER
HYD Q/C
12'10" STICK
34 INCH TG SHOES
EMPIRE 60" FBRC SAND BUCKET
Features